> TSB's > 2005 Ram
Ram truck Please visit Geno's Garage for truck accessories
Geno's garage Truck Acessories

2005 Dodge Ram Truck Technical Service Bulletins

Visit Geno's Garage
for Truck accessories.
Geno's Garage Truck Accessories

Technical Service Bulletins and Service Campaigns
2005 DH/DR/D1 - Ram Pickup All Groups / All Engines

      Group: 02 - Suspension


  Group: 03 - Rear Axle


  Group: 08 - Electrical

  08-027-04 Safety Systems - Vehicle Modifications/Repair
  08-013-05 UConnect Hands Free Phone Inoperative
  08-014-05 Mopar Accessory Remote Starter Inoperative Due To Hood Switch
  08-015-05 Powertrain Control Module Initialization
  08-024-05 Radio Communication Equipment Installation Recommendations
  08-058-05 Revised Radio Antenna Mast Installation Procedure
  08-002-06 Crackle/Pop/Static From Audio System

  Group: 09 - Engine

  09-001-06 Belt Chirp - 3.7L engine
  09-004-06 Accessory Drive Belt Chirp At Shut Down

  Group: 11 - Exhaust

  11-002-05 Vibration At Idle

  Group: 09 - Engine

  09-013-04 Gasoline Engine Oil Quality And Viscosity Grades

  Group: 13 - Frame and Bumpers


  Group: 14 - Fuel

  14-002-05 Inactive Throttle Body In Cold Ambient Temperatures
  14-003-05 Superseded by TSB 14-003-06
  14-004-05 Electronic Fuel Control (EFC) Actuator Available For Service
  14-003-06 Cummins Diesel Diagnostics

  Group: 18 - Vehicle Performance

  18-006-04 Generic Powertrain Control Module (PCM) Procedure
  18-033-04 Generic Cummins Engine Control Module (ECM) Procedure
  18-013-05A Flash: Idle Fluctuation/Diagnostic Trouble Codes
  18-015-05 Idle Speed Vibration Or Gear Rattle In Neutral With G56 Transmission
  18-027-05 Flash: All Vehicles- Evaporative Leak Detection Monitor Enhancement;
Ram Quad Cab vehicles - Cold Start Rough Idle and MIL Illumination with DTC’s P0330, and/or P0740
  18-028-05A Superseded by TSB 18-016-07
  18-029-05 Co-Pilot Support and Correct Cable Usage
  18-037-05 Flash Programming Failure Recovery Using DRBIII
  18-022-06 Superseded by TSB 18-022-07
  18-016-07 Flash: MIL Illumination Due To DTC P0430 / P0420 - Catalyst Efficiency
  18-022-07 Flash: 5.9L Turbo-Diesel Engine System Enhancements
  18-030-07 Engine Off-Idle Speed Limit Feature To Protect Turbocharger When Vehicle Is Not Moving

  Group: 19 - Steering

  19-010-04 Power Steering Fluid Contamination
  19-012-04 Superseded by TSB 19-003-05
  19-003-05 In And Out Movement In Steering Column
  19-008-05A Revised Power Steering System Bleeding Procedures

  Group: 21 - Transmission

  21-015-05 45RFE / 545RFE Trans - Delayed Engagement Due To Cooler Return Filter Replacement
  21-016-05 Superseded by TSB 21-007-06
  21-018-05 Superseded by TSB 21-008-06
  21-006-06 Transmission Jumps Out Of Reverse
  21-007-06 RFE Transmission Filters - Delayed Engagement And Related Transmission DTC'S
  21-008-06 Automatic Transmission Diagnostic Tear Down Procedure
  21-010-06 Automatic Transmission Fluid Usage ATF+4 (Type MS9602)
  21-006-07 Flash: New 48RE Feature That Allows Normal Shift Schedule With Full Disable Of 4th Gear Overdrive
  21-009-07 48RE Transmission - 1-2 Shift Hunt At Light Throttle

  Group: 22 - Wheels/Tires

  22-01-97* Discussion about radial tire runout
  22-004-03 Superseded by TSB 22-001-05
  22-001-05 Chrome Wheel Care
  22-003-06 Power Wagon - Leads Or Drifts Only To The Right On Low Crown Roads

  Group: 23 - Body

  23-043-04 Superseded by TSB 23-015-05
  23-015-05 Superseded by TSB 23-020-06
  23-022-05 Superseded by TSB 23-036-07
  23-027-05 Tonneau Cover Installation
  23-035-05 Circular/Ring Marks On Glass
  23-046-05A Superseded by TSB 23-009-06
  23-049-05 Drip Rail Door Seal Torn
  23-009-06 Water Leak At Roof Mounted Marker Lamps
  23-014-06 Windshield Wiper Blade/Element Maintenance
  23-020-06 Transit Film Removal
  23-013-07 Trailer Towing Mirror - New Mirror Glass Locking Tab - New Removal Procedure
  23-036-07 Low Gloss Interior Trim

  Group: 24 - Heating and Air Conditioning

  24-013-05 A/C Cooling Coil Odor

  Group: 25 - Emissions Control

  25-001-04 Evaporative Systems Service
  25-001-06 Positive Crankcase Ventilation (PCV) System Freezes In Extreme Cold Ambient

  Group: 26 - Revisions

  26-dr06-05 2005 Service Manual Revision - CLUTCH pages 05DR6-1 through 05DR6-8B
  26-003-07 Fluid Flushing Requirements

  Group: 28 - Service Campaigns

  28-D46-06 Reprogram PCM - OBD Fuel System Monitor
  28-ie17-06 Safety Recall E17 - Out-of-Park Alarm System

I would like to thank Bob Bergevin, Arthur Cantrall, Barry Drodge, David Lovell, Bill Maurits, and Steve for supplying the information for these bulletins. And a big thank you goes to Geno's Garage for making possible.


  Top of Page Home  


This page was edited on: February 21, 2008